BD Chemical Co. Inc.
Material Safety Data Sheet
Manufacturer’s Name: Crystal Packaging,. Inc.
Address: 5185 National Western Dr. Telephone Number: 303-778-1805
Denver, CO 80216 Date Prepared: 07/24/08
PRODUCT NAME: LIQUID SOUR SOFTENER
PRODUCT CODE: D7104
SECTION II: Hazardous Ingredients/Identity Information
Hazardous Components CAS# OSHA PEL ACGIH TLV Other
Phosphoric acid 7664-38-2 1mg/cu3 1mg/cu3
SECTION III: Physical/Chemical Characteristics
Boiling Point: Approximately 195ºF Specific Gravity: 1.047
Vapor Pressure: NA Melting Point: NA
Vapor Density: Heavier than air Evaporation Rate: Slower than ether
Solubility in water: Complete
Appearance and Odor: Pink liquid with fresh scent.
SECTION IV: Fire and Explosion Hazard Data
Flash Point: Liquid non-flammable.
Flammable Limits: NA LEL: NA UEL: NA
Extinguishing Media: Carbon dioxide, dry chemical, foam or water class A, BC, or ABC fire extinguishers.
Special Fire Fighting Procedures: Water can be used to cool containers adjacent to fire
Unusual Fire and Explosion Hazards: Pressure may develop in closed containers if temperatures over 195°F are reached.
SECTION V: Reactivity Data
Conditions to Avoid: NA
Incompatibility: Strong oxidizing agents, acids or anything reactive with water.
Hazardous Decomposition or Byproducts: We have no studies of this product.
Hazardous Polymerization: Will not occur.
LIQUID SOUR SOFTNER PAGE 2
SECTION VI: Health Hazard Data
Routes of Entry: Eye contact, Skin contact, Inhalation, and Ingestion
Effects of Overexposure
Eyes: Contact will be painful and irritating.
Skin: Prolonged severe irritation or burns will result from contact.
Inhalation: Will irritate nose, throat and chest and cause coughing.
Emergency and First Aid Procedures
Eyes: Flush with water for 15 minutes holding eyelids apart to ensure flushing of the entire eye.
Skin: Flush with water for 15 minutes and remove contaminated clothing and footwear.
Inhalation: Remove to fresh air. If breathing has stopped artificial respiration should be started. If any symptoms persist, contact a physician immediately.
Ingestion: Contact a physician immediately. Do not induce vomiting!
SECTION VII: Precautions for Safe Handling and Use
Steps to be taken in Case Material is released or spilled: For minor spills neutralize with, baking soda. Soak up with sweeping compound and or sand and transfer to a disposal container.
Waste Disposal Method: In accordance with all federal, state, and local regulations.
Precautions to Be Taken in Handling and Storing: Storage between 40°F and 100°F are recommended.
Other Precautions: Do not take internally or inhale vapors. Avoid eye contact.
SECTION VIII: Control Measure
Respiratory: Recommended for high vapor concentration.
Local Exhaust: Preferable
Mechanical (General): Acceptable
Protective Gloves: Plastic or NBR gloves
Eye Protection: Chemical safety goggles
Other Protective Clothing or Equipment: Usually not needed unless splashing is excessive.
NA-Not Applicable NI- No Information